In today's fast-growing internet era, the electronic industry is developing rapidly, in which cable maintenance is particularly important. What do you know about Jinan cable bridge? Do you know how to repair and maintain cable trays? Don't worry, guys. Next, the cable tray manufacturer will introduce some relevant contents about bridge maintenance, hoping to be helpful to you.

一、濟南電纜橋架的維修工作

1、 Maintenance of cable tray in Jinan

1、涂層處理

1. Coating treatment

涂層工藝分為刷涂、滾涂。刷涂或者滾涂時每層應從橫交錯反復進行涂，直到均勻?yàn)橹?，不能出現漏涂。

The coating process is divided into brush coating and roll coating. During brushing or roller coating, each layer shall be applied repeatedly in a staggered manner until it is uniform, and there shall be no missing coating.

2、銹跡處理

2. Rust treatment

通常電纜橋架采用氯磺化底漆二道進行兩部分除銹，表面除銹處理質量直接影響防腐工程的壽命，現場除銹通常是砂輪機或者人工除銹，在表面處理之后，在4小時內涂上底漆。如果處理不當發現有新銹，需要進行重新處理。

Generally, two coats of chlorosulfonated primer are used for two-part derusting of cable tray. The quality of surface derusting treatment directly affects the service life of anti-corrosion engineering. On site derusting is usually carried out by grinder or manual derusting, and the primer is applied within 4 hours after surface treatment. If new rust is found after improper treatment, it needs to be reprocessed.

3、施工環境要求

3. Construction environment requirements

環境需要通風良好，溫度在13℃-30℃，不得低于5℃，相對濕度保持在百分之80以內。不宜在強烈日光下施工。遇到雨、霧、強風氣候不得在室外進行施工。

The environment shall be well ventilated, the temperature shall be 13 ℃ - 30 ℃, not less than 5 ℃, and the relative humidity shall be kept within 80%. Construction should not be carried out under strong sunlight. In case of rain, fog and strong wind, construction shall not be carried out outdoors.

二、濟南電纜橋架的維護

2、 Maintenance of cable tray in Jinan

1、避免與腐蝕性液體接觸。

1. Avoid contact with corrosive liquids.

2、可用電纜橋架專用的保養蠟進行保養。

2. The special maintenance wax for cable tray can be used for maintenance.

3、定期清理電纜橋架表面的灰塵與銹跡。

3. Regularly clean the dust and rust on the surface of cable tray.

4、避免擺放在高溫潮濕地方。

4. Avoid placing in hot and humid places.

本文由濟南電纜橋架為您提供，我們的網站是：http://www.hongxingbm.com我們將以全心全意的熱情為您提供服務，歡迎您的訪問

This article is provided by Jinan cable bridge. Our website is: http://www.hongxingbm.com We will provide you with services with wholehearted enthusiasm. Welcome to visit